NuTone 78V Instruction Manual download pdf

Single Pole (One location)

Quiet Fan Speed Control

Rating: 1.5A-120 VAC, 60Hz

INSTALLATION INSTRUCTIONS

FEATURES

• Four Preset fan levels • Ideal for any area where ceiling fan noise is distracting

• Large ON/OFF switch

INSTALLATION INSTRUCTIONS

WARNING: TO BE INSTALLED AND/OR USED IN ACCORDANCE WITH APPROPRIATE ELECTRICAL CODES AND REGULATIONS.

WARNING: IF YOU ARE NOT SURE ABOUT ANY PART OF THESE INSTRUCTIONS, CONSULT A QUALIFIED ELECTRICIAN.

WARNING: TO AVOID OVERHEATING AND POSSIBLE DAMAGE TO THIS DEVICE AND OTHER EQUIPMENT, DO NOT INSTALL TO CONTROL A

RECEPTACLE, FLUORESCENT LIGHTING, A MOTOR- OR A TRANSFORMER-OPERATED APPLIANCE OTHER THAN APPROPRIATE CEILING FANS.

WARNING: TO REDUCE THE RISK OF FIRE OR ELECTRICAL SHOCK, THIS CONTROL IS TO BE USED WITH CEILING FANS THAT ARE MARKED AS

SUITABLE FOR USE WITH A SOLID-STATE FAN SPEED CONTROL AND IS RATED 120 VOLTS AC, TOTAL LOAD 1.5 AMPERES MAXIMUM.

WARNING: FOR USE ON CEILING PADDLE FANS WITH SPLIT-CAPACITOR OR SHADED POLE MOTORS ONLY. PLEASE REFER TO FAN

MANUFACTURER’S INSTRUCTIONS OR RATING LABEL ON THE MOTOR TO CONFIRM TYPE. USE WITH ANY OTHER TYPES OF MOTORS OR

EQUIPMENT MAY CAUSE OVERHEATING AND/OR DAMAGE TO THE MOTORS OR EQUIPMENT.

OTHER CAUTIONS:

1. USE ONLY ONE (1) SPEED CONTROL PER LOAD (LOAD CAN BE ONE OR

MULTIPLE FANS).

2. DISCONNECT POWER WHEN SERVICING FIXTURE.

3. USE THIS DEVICE ONLY WITH COPPER OR COPPER CLAD WIRE. WITH

ALUMINUM WIRE USE ONLY DEVICES MARKED CO/ALR OR CU/AL.

MULTI-FAN CONTROL:

Any number of fans of the same type may be controlled by a single fan speed

control provided that the total amperage of the fans do not exceed the amperage

of the fan speed control.

MULTI-GANG INSTALLATION:

There is NO derating necessary for multi-gang installations of this Quiet Fan Speed control.

TO INSTALL:

1. WARNING: TO AVOID FIRE, SHOCK, OR DEATH; TURN OFF POWER AT CIRCUIT BREAKER OR

FUSE AND TEST THAT POWER IS OFF BEFORE WIRING!

2. Remove existing wallplate and switch, if applicable.

3. Remove 5/8" (1.6 cm) of insulation from each circuit conductor. Make sure the ends of wires are straight.

4. Connect wires per WIRING DIAGRAM as follows: Twist strands of each lead tightly and, with circuit

conductors push firmly into appropriate wire connector. Screw connectors on clockwise making sure no

bare wires show below the wire connectors. Secure each connector with electrical tape.

5. Installation may now be completed by carefully positioning all wires to provide room in outlet box for

control. Mount control into box with mounting screws supplied. Attach Decora

wallplate.

6. Restore power at circuit breaker or fuse. Check for proper operation by positioning the knob to each of

the four levels: MAX, HIGH, MEDIUM and LOW (refer to Figure 1). Ensure that fan speed changes

accordingly.

7. INSTALLATION IS COMPLETE.

TO OPERATE

• Turn control knob to ON position (one of four levels: MAX, HIGH,

MEDIUM, or LOW)

- Fan will turn ON at level set by knob control.

• Rotate knob control to each of the four levels; MAX, HIGH, MEDIUM,

and LOW

- Fan will increase or decrease in speed respectively for desired

level.

• Rotate knob control to OFF position

- Fan will turn OFF.

TROUBLESHOOTING

• Fan does not turn ON or does not run Multispeed

- Circuit breaker or fuse has tripped.

- Fan is not connected to line Neutral.

- Switch on Fan not set to HIGH position.

Figure 1 - Fan Speed Control Functions

Rotary

ON/OFF

Switch

Mounting

Strap

WIRE CONNECTOR / # OF CONDUCTOR COMBINATION CHART

1- #12 w/ 1 to 3 #14, #16 or #18

2- #12 w/ 1 #14 w/ 1 #16 or #18

2- #12 w/ 1 #16 w/ 1 or 2 #18

2- #14 w/ 1 to 3 #16, #18 or #20

4- #16 w/ 1 or 2 #18, #20 or #22

1- #14 w/ 1 to 4 #16, #18 or #20

2- #14 w/ 1 to 3 #16, #18 or #20

2- #14 w/ 1 #16 w/ 1 or 2 #18 or #20

3- #14 w/ 1 or 2 #18 or #20

4- #14 w/ 1 #16 or #18

2- #16 w/ 1 #18 w/ 1 or 2 #20 or #22

1- #14 w/ 1 #18 w/ 1 to 3 #20

3- #14 w/ 1 #16 w/ 1 #18, #20, #22

3- #14 w/ 1 #18 w/ 1 #20 or #22

Hot (Black)

Neutral (White)

Fan

Fan Speed

Black

Green

Ground

Black

White

Red

Line

120VAC, 60Hz

Wiring Diagram 1 - Single Location Control Application

MODEL

78V / 78W

BROAN-NUTONE ONE YEAR LIMITED WARRANTY

Broan-NuTone warrants to the original consumer purchaser of its

products that such products will be free from defects in materials or

workmanship for a period of one year from the date of original purchase.

THERE ARE NO OTHER WARRANTIES, EXPRESS OR IMPLIED,

INCLUDING, BUT NOT LIMITED TO, IMPLIED WARRANTIES OF

MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE.

During this one-year period, Broan-NuTone will, at its option, repair or

replace, without charge, any product or part which is found to be

defective under normal use and service.

THIS WARRANTY DOES NOT EXTEND TO FLUORESCENT LAMP

STARTERS AND TUBES. This warranty does not cover (a) normal

maintenance and service or (b) any products or parts which have been

subject to misuse, negligence, accident, improper maintenance or

repair (other than by Broan-Nutone), faulty installation or installation

contrary to recommended installation instructions.

The duration of any implied warranty is limited to the one-year period

as specified for the express warranty. Some states do not allow

limitation on how long an implied warranty lasts, so the above limitation

may not apply to you.

BROAN-NUTONE’S OBLIGATION TO REPAIR OR REPLACE, AT

BROAN-NUTONE’S OPTION, SHALL BE THE PURCHASER’S SOLE

AND EXCLUSIVE REMEDY UNDER THIS WARRANTY. BROAN-

NUTONE SHALL NOT BE LIABLE FOR INCIDENTAL, CONSEQUEN-

TIAL OR SPECIAL DAMAGES ARISING OUT OF OR IN CONNEC-

TION WITH PRODUCT USE OR PERFORMANCE. Some states do not

allow the exclusion or limitation of incidental or consequential dam-

ages, so the above limitation or exclusion may not apply to you.

This warranty gives you specific legal rights, and you may also have

other rights, which vary from state to state. This warranty supersedes

all prior warranties.

To qualify for warranty service, you must (a) notify Broan-NuTone at the

address or telephone number below, (b) give the model number and

part identification and (c) describe the nature of any defect in the

product or part. At the time of requesting warranty service, you must

present evidence of the original purchase date.

Broan-NuTone LLC, 926 West State Street, Hartford, WI 53027

(1-800-637-1453)

DI-41X-RTF01-12B

99042151F

1 2

78V / 78W 1

Summary of Contents

Page 1 - 78V / 78W

Single Pole (One location)Quiet Fan Speed ControlRating: 1.5A-120 VAC, 60HzINSTALLATION INSTRUCTIONSFEATURES• Four Preset fan levels • Ideal for any a

Page 2

Unipolar (una ubicación)Control silencioso de velocidadpara ventiladoresCapacidad nominal: 1.5 A-120 VCA, 60 HzINSTRUCCIONES DE INSTALACIÓNCARACTERÍST

Comments to this Manuals

No comments

NuTone 78V Instruction Manual

Browse online or download Instruction Manual for Unknown NuTone 78V. NuTone 78V Instructions / Assembly User Manual

Summary of Contents

Comments to this Manuals

Related products and manuals for Unknown NuTone 78V